非平衡条件下氯化锰-氨的吸附/解吸特性分析

上海交通大学学报（自然版） ›› 2016, Vol. 50 ›› Issue (04): 583-587.

非平衡条件下氯化锰-氨的吸附/解吸特性分析

周志松，江龙，王丽伟，王如竹，高鹏

（上海交通大学制冷与低温工程研究所，上海 200240）

收稿日期:2015-03-28 出版日期:2016-04-28 发布日期:2016-04-28
基金资助:
国家自然科学基金优秀青年项目（51222601）资助

Adsorption/Desorption NonEquilibrium Characteristics of Composite MnCl2NH3 Working Pair

ZHOU Zhisong，JIANG Long，WANG Liwei，WANG Ruzhu，GAO Peng

(Institute of Refrigeration and Cryogenics Engineering, Shanghai Jiaotong University, Shanghai 200240, China)

Received:2015-03-28 Online:2016-04-28 Published:2016-04-28

摘要/Abstract

摘要： 摘要：研究了非平衡条件下氯化锰复合吸附剂吸附氨的压力/温度曲线，并与Claperon反应平衡曲线进行了对比.结果发现，在相同的冷凝/蒸发条件下，氯化锰吸附（解吸）氨的量随着温度的变化而变化，说明非平衡吸附/解吸过程为双变量控制，而不是单变量控制.这一研究结果与理论上的Claperon曲线有较大的差别.为了验证研究结果，对吸附剂的等压吸附过程进行了测试.结果表明：吸附过程与平衡压力/温度曲线相符合；解吸过程则存在着严重的滞后现象，并且该现象主要在解吸4 mol氨之后出现.考虑解吸滞后条件，计算了单级吸附制冷系统的制冷系数(COP)和单位质量吸附剂的制冷功率(SCP)，结果显示，按照传统理论所得到的COP和SCP与实际测试结果的误差分别达到25%与40%，说明对于化学吸附制冷过程的理论计算需要以非平衡吸附性能测试作为基础.

关键词: 非平衡, 解吸, 吸附, 氯化锰, 氨

Abstract: Abstract： This paper investigated the adsorption/desorption nonequilibrium characteristics of composite MnCl2NH3 working pair by comparing with the Clapeyron reaction equilibrium curve. The experimental results showed that under the same condensation/evaporation conditions, for the sorption/desorption process of MnCl2NH3 the Clapeyron curves for different sorption molar quantities were different, i.e., the process of nonequilibrium sorption/desorption was controlled by dual variables, rather than a single variable. The results were much different from theoretical Clapeyron curves. To verify the results, the isobaric sorption process of sorbent was tested. The results showed that the adsorption process was in accord with the experimental Clapeyron curves, whereas the serious desorption hysteresis existed especially for the sorption quantity of 4 mol mol-1. By considering the results of desorption hysteresis, the coefficient of performance (COP) and specific cooling power (SCP) of the working pair were analyzed. A comparison of the equilibrium theoretical and the experimental nonequilibrium analysis results showed that the error of conventional theoretical results of COP and SCP reached 25% and 40%, respectively, indicating that the performance analysis of chemical sorption refrigeration processes should be based on the nonequilibrium sorption performance test.

Key words: Key words： nonequilibrium, desorption, adsorption, manganese chloride, ammonia

中图分类号:

TB 64
TB 61

周志松，江龙，王丽伟，王如竹，高鹏. 非平衡条件下氯化锰-氨的吸附/解吸特性分析[J]. 上海交通大学学报（自然版）, 2016, 50(04): 583-587.

ZHOU Zhisong，JIANG Long，WANG Liwei，WANG Ruzhu，GAO Peng. Adsorption/Desorption NonEquilibrium Characteristics of Composite MnCl2NH3 Working Pair[J]. Journal of Shanghai Jiaotong University, 2016, 50(04): 583-587.

参考文献

［1］LI T X, WANG R Z, LI H. Progress in the development of solidgas sorption refrigeration thermodynamic cycle driven by lowgrade thermal energy ［J］. Progress in Energy and Combustion Science, 2014, 40(2)：158. ［2］梁杰荣, 李廷勋. 基于SINDA/FLUINT平台的R290房间空调器仿真［J］. 低温与超导, 2011, 39 (2): 4246． LIANG Jierong, LI Tingxun. R290 room airconditioner simulation based on SINDA /FLUINT ［J］. Cryogenics and Superconductivity, 2011, 39(2)：4246. ［3］WANG LW, WANG R Z, LU Z S, et al. Studies on heat pipe type adsorption icemaker for fishing boats: Choice of heat pipe medium and experiments under unsteady heating sources［J］. Energy Conversion and Management, 2006, 47(15/16)： 20812091. ［4］WONGSUWAN W, KUMAR S, NEVEU P, et al. A review of chemical heat pump technology and applications［J］. Applied Thermal Engineering, 2001, 21(15)： 14891519. ［5］VASILIEV L L, MISHKINIS D A, ANTUKH A A, et al. Solargas solid sorption refrigerator［J］. Adsorption, 2001, 7(2)： 149161. ［6］LI T X, WANG R Z, KIPLAGAT J K. Performance analysis of an integrated energy storage and energy upgrade thermochemical solidgas sorption system for seasonal storage of solar thermal energy［J］. Energy, 2013, 50(2)： 454467. ［7］YU N, WANG R Z, WANG L W, et al. Sorption thermal storage for solar energy［J］. Progress in Energy and Combustion Science，2013，39(5)： 489514. ［8］NEVEU P, CASTAING J. Solidgas chemical heat pumps: Field of application andperformance of the internal heat of reaction recovery process［J］. Heat Recovery System & CHP, 1993, 13(3)： 233251. ［9］WANG K, WU J Y. Effective thermal conductivity of expanded graphiteCaCl2 composite adsorbent for chemical adsorption chillers［J］. Energy Conversion and Management, 2006, 47(8)： 19021912. ［10］WANG L W, METCALF S J, THORPE R, et al. Development of thermal conductive consolidated activated carbon for adsorption refrigeration［J］. Carbon, 2012, 50(3)： 977986.

[1]	魏晓静, 翟双岭, 石鑫, 高多龙, 闻小虎, 刘冬梅, 任天辉. 铜氨络合物对二乙基羟胺除氧缓蚀性能的影响[J]. 上海交通大学学报, 2022, 56(6): 818-826.
[2]	张贤楠, 冷远逵, 武卫杰, 李万万. 聚乙二醇接枝苯乙烯马来酸共聚物复合微球的制备和检测应用[J]. 上海交通大学学报, 2021, 55(9): 1064-1070.
[3]	谭富欣, 李子昊, 周佳, 张书宇. 新型C3-含硅基取代手性脯氨酸型催化剂的高效构筑[J]. 上海交通大学学报, 2021, 55(9): 1058-1063.
[4]	张金柯, 缪光武, 金佳敏, 陈银飞, 卢晗锋, 宁文生, 白占旗, 刘武灿. R115/NaX的吸附动力学及其因素显著性分析[J]. 上海交通大学学报, 2021, 55(9): 1071-1079.
[5]	吴诗辉, 贾军, 鲍然, 周宇, 夏青元. 面向集群对抗的多弹协同目标分配模型与仿真分析[J]. 空天防御, 2021, 4(3): 1-9.
[6]	李芹, 杨肖峰, 董威, 杜雁霞. 高超声速飞行器表面吸附特性对多相催化过程影响的数值模拟[J]. 上海交通大学学报, 2021, 55(11): 1352-1361.
[7]	韩红桂, 杨士恒, 张璐, 乔俊飞. 城市污水处理过程出水氨氮优化控制[J]. 上海交通大学学报, 2020, 54(9): 916-923.
[8]	彭佳杰, 潘权稳, 葛天舒, 王如竹. 太阳能热驱动的吸附式冷热联供系统性能测试[J]. 上海交通大学学报, 2020, 54(7): 661-667.
[9]	刘晓东，吴磊，孔谅，王敏，陈一东. 空气等离子处理对碳纤维增强复合材料表面特性及胶接性能的影响[J]. 上海交通大学学报, 2019, 53(8): 971-977.
[10]	贾振. GSPU保温管节点补口自动开合浇注模具的开发[J]. 海洋工程装备与技术, 2016, 3(1): 52-57.
[11]	李兰, 张荫纳. 静态柔性软管弯曲加强器的设计[J]. 海洋工程装备与技术, 2014, 1(3): 223-226.
[12]	周志琨, 杨淞, 金桂华, 王俊伟, 赵言正. 壁面粘贴质量检测系统设计[J]. 上海交通大学学报, 2014, 48(11): 1536-1540.
[13]	蒋晓斌, 张晓灵, 吴文通, 孔瑞林, 杨加栋, 杜宝银. 复合聚氨酯保温管道试制中常见缺陷和处理方法[J]. 海洋工程装备与技术, 2014, 1(1): 80-83.
[14]	闫霆1,李卉2,马良1,王如竹1,李廷贤1. 基于热化学再吸附变温原理的低品位热能升温储能特性[J]. 上海交通大学学报（自然版）, 2013, 47(11): 1717-1722.
[15]	陆跃，饶炬，龚飞荣，陈建定. 聚己内酯型聚羟基氨基甲酸酯的合成[J]. 上海交通大学学报（自然版）, 2013, 47(05): 827-833.