表面能对过冷水中冰生长的影响

上海交通大学学报（自然版） ›› 2016, Vol. 50 ›› Issue (04): 588-584.

表面能对过冷水中冰生长的影响

王静，孔维梁，王福新，刘洪

(上海交通大学航空航天学院，上海 200240)

收稿日期:2015-04-17 出版日期:2016-04-28 发布日期:2016-04-28

Experimental Study of Surface Energy on Growth of Icing in Supercooled Water

WANG Jing，KONG Weiliang，WANG Fuxin，LIU Hong

(School of Aeronautics and Astronautics, Shanghai Jiaotong University, Shanghai 200240， China)

Received:2015-04-17 Online:2016-04-28 Published:2016-04-28

摘要/Abstract

摘要： 摘要：通过实验观察了过冷水在壁面上的结冰过程，采用高速相机分别记录水平和竖直2个方向的冰生长过程.分别研究了接触角和导热率2个壁面材料参数对冰生长的影响，并且针对接触角影响结冰的机制进行了探讨.结果显示：壁面导热率可明显改变壁面上冰的速度和形态；接触角对结冰速度改变较少，但在导热率低时影响大.

关键词: 表面能, 壁面结冰, 结冰速度, 接触角, 导热率

Abstract: Abstract： Icing on the airplane is an important factor for the safety of aviation, but the impact of surfaces on icing growth is not fully understood. In this paper, the icing process of the supercooling water on the substrate was studied. The vertical and horizontal growth of ice were recorded respectively by using 2view high speed cameras.The influence of contact angle and thermal conductivity on the ice growth was studied respectively. The influence of contact angle and surface energy on horizontal ice growth was analyzed in detail. The results show that the thermal conductivity can significantly influence the horizontal velocity and shape ofice.The contact angle has little influence on thehorizontal velocity when the thermal conductivity is large,but it has a great influence at a lower thermal conductivity.

Key words: Key words： surface energy, icing on substrate, velocity of icing, contact angle, thermal conductivity

中图分类号:

V 241.01

王静，孔维梁，王福新，刘洪. 表面能对过冷水中冰生长的影响[J]. 上海交通大学学报（自然版）, 2016, 50(04): 588-584.

WANG Jing，KONG Weiliang，WANG Fuxin，LIU Hong. Experimental Study of Surface Energy on Growth of Icing in Supercooled Water[J]. Journal of Shanghai Jiaotong University, 2016, 50(04): 588-584.

参考文献

［1］MYERS T G,HAMMONDD W. Ice and water film growth from incoming supercooled droplets［J］.International Journal of Heat and Mass Transfer, 1999，42（12）：22332242. ［2］WANG G，ROTHMAYER A P. Thin water films driven by air shear stress through roughness［J］.Computers & Fluids, 2009， 38（2）： 235246. ［3］KONG Weiliang, LIU Hong. Development and theoretical analysis of an aircraft supercooledicing model［J］.Journal of Aircraft, 2014， 51(3)： 975986. ［4］AHIBKOV A A， ZHELTOV M A, KOROLEVA A，et al. Crossover from diffusionlimited to kineticslimited growth of ice crystals［J］.Journal of Crystal Growth, 2005， 285（12）： 215227. ［5］LACOMBE J C，KOSS M B，FREI J E，et al. Evidence for tip velocity oscillations in dendritic solidification［J］.Physical Review E, 2002， 65：(031604)16. ［6］LIDIYA Mishchenko, BENJAMIN Hatton, VAIBHAV Bahadur, et al. Design of Icefree Nanostructured Surfaces Based on Repulsion of Impacting Water Droplets［J］.ACSNANO, 2010， 4(12)： 76997707. ［7］PETER Conrad, GEORGE E Ewing. Ice nucleation on BaF2(111)［J］.The Journal of Chemical Physics, 2005， 122(6)：(064709)112. ［8］SARKAR D K，FARZANEH M. Superhydrophobic coatings with reduced ice adhesion ［J］.Journal of Adhesion Science and Technology, 2009， 23(9)：12151237. ［9］PETRENKO V F，PENG A. Reduction of ice adhesion to metal by using selfassembling monolayers (SAMs)［J］.Canada. Journal of Physics, 2003， 81(12)： 387393. ［10］KULINICH S A，FARZANEH M. Ice adhesion on superhydrophobic surfaces［J］.Applied Surface Science, 2009， 255(18)： 81538157. ［11］KRIPA K Varanasi, DENG Tao, J David Smith, et al. Frost formation and ice adhesion on superhydrophobic surfaces［J］.Applied Physics Letters,2010，97(23)：(234102)112. ［12］CAO Liangliang, ANDREW K Jones, VINOD K Sikka, et al. Antiicing superhydrophobic coatings［J］. Langmuir letters, 2009， 25(21)： 1244412448. ［13］LINDENMEYER C S, ORROK G T, JACKSON K A，et al. Rate of growth of ice crystals in supercooled water［J］.The Journal of Chemical Physics, 1957， 27(3)： 882. ［14］BRENER E A，SAITO Y，KRUMBHAAR H M，et al. Growth of an acicular crystal near a wall［J］. JETP Letter, 1995， 61(4)： 298302. ［15］QIN Frank G F，YANG Minlin, YANG Xiaoxi. Experimental and thermal analysis ofwashing the packed ice bed in wash columns［J］.American Institute of Chemical Engineers, 2009， 55(11)： 28352847. ［16］QIN Frank G F, CHEN Xiaodong, MOHAMMED M Farid. Growth kinetics of ice films spreading on a subcooled solid surface［J］.Separation and Purification Technology， 2004， 39(1)：109121.

[1]	沈佳瑛，孔维梁，刘洪. 壁面表面能影响冰枝尖端生长机制研究[J]. 上海交通大学学报（自然版）, 2018, 52(8): 918-923.
[2]	陈彦君，李元阳，刘振华. 固-液接触角对池内核态沸腾换热特性的影响[J]. 上海交通大学学报（自然版）, 2015, 49(01): 135-140.
[3]	黄苏和，胡海豹，陈立斌，宋东. 剪切气流驱动下微沟槽表面液滴受力分析[J]. 上海交通大学学报（自然版）, 2014, 48(02): 260-264.
[4]	龚帅,郑平. 液滴在非均匀润湿表面上的动力行为[J]. 上海交通大学学报（自然版）, 2014, 48(02): 239-244.
[5]	潘光, 黄桥高, 刘占一, 胡海豹, 宋保维. 基于低表面能效应的疏水表面减阻机理[J]. 上海交通大学学报（自然版）, 2011, 45(10): 1440-1443.