Model Predictive Control for Steering System of Water-Jet Propulsion

doi:10.1007/s12204-019-2141-z

Journal of Shanghai Jiao Tong University (Science) ›› 2020, Vol. 25 ›› Issue (3): 299-303.doi: 10.1007/s12204-019-2141-z

Previous Articles Next Articles

Model Predictive Control for Steering System of Water-Jet Propulsion

GONG Zhenghua (龚征华), SONG Chenwei (宋晨维), LI Gangqiang (李刚强), CHEN Jianping (陈建平), XU Zijing (徐梓京), YUAN Jingqi (袁景淇)

(1. MOE Key Laboratory of Marine Intelligent Equipment and System, Shanghai Jiao Tong University, Shanghai 200240, China; 2. Laboratory of Science and Technology on Waterjet Propulsion, Shanghai 200011, China; 3. Marine Design & Research Institute of China, Shanghai 200011, China; 4. Department of Automation, Shanghai Jiao Tong University, Shanghai 200240, China)
(1. MOE Key Laboratory of Marine Intelligent Equipment and System, Shanghai Jiao Tong University, Shanghai 200240, China; 2. Laboratory of Science and Technology on Waterjet Propulsion, Shanghai 200011, China; 3. Marine Design & Research Institute of China, Shanghai 200011, China; 4. Department of Automation, Shanghai Jiao Tong University, Shanghai 200240, China)

Online:2020-06-15 Published:2020-05-29
Contact: YUAN Jingqi (袁景淇) E-mail:jqyuan@sjtu.edu.cn

Abstract

Abstract: Water-jet propulsion is a widely applied ship propulsion technology. Its steering control system has an important impact on manoeuvre performance. In this paper, transfer function model is firstly established on the basis of mechanism analysis of water-jet steering system. Then, by considering the variability of model parameters and input constraints in practical operation, a model predictive controller is designed for steering system control. Subsequently, model based disturbance observer is employed in an attempt to reject environmental disturbances. The performance of the proposed model predictive control (MPC) scheme for a particular steering system is compared with that of conventional proportional integral derivative (PID) control strategy. Simulation results demonstrate that the proposed model predictive controller outperforms conventional PID controller, particularly in robustness, response delay and tracking accuracy.

Key words: water-jet propulsion| steering system| model predictive control (MPC)| disturbance observer

摘要： Water-jet propulsion is a widely applied ship propulsion technology. Its steering control system has an important impact on manoeuvre performance. In this paper, transfer function model is firstly established on the basis of mechanism analysis of water-jet steering system. Then, by considering the variability of model parameters and input constraints in practical operation, a model predictive controller is designed for steering system control. Subsequently, model based disturbance observer is employed in an attempt to reject environmental disturbances. The performance of the proposed model predictive control (MPC) scheme for a particular steering system is compared with that of conventional proportional integral derivative (PID) control strategy. Simulation results demonstrate that the proposed model predictive controller outperforms conventional PID controller, particularly in robustness, response delay and tracking accuracy.

关键词: water-jet propulsion| steering system| model predictive control (MPC)| disturbance observer

CLC Number:

TP 391

GONG Zhenghua, SONG Chenwei, LI Gangqiang, CHEN Jianping, XU Zijing, YUAN Jingqi . Model Predictive Control for Steering System of Water-Jet Propulsion[J]. Journal of Shanghai Jiao Tong University (Science), 2020, 25(3): 299-303.

References 11

[1]	DONG Z L, ZHANG Q, HAN S F. Control of an electrohydraulic steering system using a PID controller with a nonlinear compensation algorithm [J]. Proceedings of SPIE, 2002, 4715: 87-95.
[2]	UNAR M A. Ship steering control using feedforward neural networks [D]. Glasgow, UK: University of Glasgow,1999.
[3]	LAYNE J R, PASSION K M. Fuzzy model reference learning control for cargo ship steering [J]. IEEE Control Systems, 1993, 13(6): 457-462.
[4]	HUO X X, HU J Q, LI Z Y. BP neural network based PID control for ship steering [C]//World Congress on Information and Communication Technologies. Dalian,China: IEEE, 2013: 1042-1046.
[5]	LEE J H, MORARIM, GARCIA C E. State-space interpretation of model predictive control [J]. Automatica,1994, 30(4): 707-717.
[6]	MAYNED Q, RAWLINGS J B, RAOC V, et al. Constrained model predictive control: Stability and optimality[J]. Automatica, 2000, 36(6): 789-814.
[7]	MORARI M, BARI′CM. Recent developments in the control of constrained hybrid system [J]. Computer and Chemical Engineering, 2006, 30(10/11/12): 1619-1631.
[8]	EDGE K A, DARLING J. Cylinder pressure transients in oil hydraulic pumps with sliding plate valves [J].Proceedings of the Institution of Mechanical Engineers,1986, 200(1): 45-54.
[9]	YANG H Y, SHI H, GONG G F, et al. Electrohydraulic proportional control of thrust system for shield tunneling machine [J]. Automation in Construction,2009, 18(7): 950-956.
[10]	CLARK D W, MOHTADI C, TUFFS P S. Generalized predictive control. Part I. The Basic Algorithm[J]. Automatica, 1987, 23(2): 137-148.
[11]	KEMPF C J, KOBAYASHI S. Disturbance observer and feed-forward design for a high-speed direct-drive positioning table [J]. IEEE Transactions on Control Systems Technology, 1999, 7(5): 513-526.

[1]	Li Songyang, Chen Wenbo, Wan Heng. Model Predictive Control Method Based on Data-Driven Approach for Permanent Magnet Synchronous Motor Control System [J]. J Shanghai Jiaotong Univ Sci, 2025, 30(2): 270-279.
[2]	LIU Yuesheng (刘月笙), HE Ning^∗(贺宁), HE Lile (贺利乐), ZHANG Yiwen (张译文), XI Kun (习坤), ZHANG Mengrui (张梦芮). Self-Tuning of MPC Controller for Mobile Robot Path Tracking Based on Machine Learning [J]. J Shanghai Jiaotong Univ Sci, 2024, 29(6): 1028-1036.
[3]	ZHANG Xiaotian¹(张啸天), HE Defeng^1* (何德峰), LIAO Fei² (廖飞). Iterative Model Predictive Control for Automatic Carrier Landing of Carrier-Based Aircrafts Under Complex Surroundings and Constraints [J]. J Shanghai Jiaotong Univ Sci, 2024, 29(4): 712-724.
[4]	JIN Feiyu (金飞宇), CHEN Longsheng^∗ (陈龙胜), LI Tongshuai (李统帅), SHI Tongxin (石童昕). Distributed Cooperative Anti-Disturbance Control for High-Order MIMO Nonlinear Multi-Agent Systems [J]. J Shanghai Jiaotong Univ Sci, 2024, 29(4): 656-666.
[5]	HE Yu, OUYANG Zilu, ZOU Lu, CHEN Weimin, ZOU Zaojian. Ship Path Following and Collision Avoidance Based on Vector Field Guidance Law and Model Predictive Control [J]. Journal of Shanghai Jiao Tong University, 2024, 58(11): 1644-1653.
[6]	LIU Chuanbin, JIAO Wenshu, WU Qiuwei, CHEN Jian, ZHOU Qian. Strategy of Wind-Storage Combined System Participating in Power System Secondary Frequency Regulation Based on Model Predictive Control [J]. Journal of Shanghai Jiao Tong University, 2024, 58(1): 91-101.
[7]	YU Te, LIU Jiapeng, WU Chao, ZHOU Chang, ZHOU Shengzeng, WANG Lei. USV and AUV Cooperative Control Strategy Based on Nonlinear Disturbance Observer [J]. Journal of Shanghai Jiao Tong University, 2023, 57(S1): 114-123.
[8]	JIANG Enyu, CHEN Yu, SHI Zhengjing, WU Zhecheng, LIN Shunfu, LI Dongdong. A Microgrid Energy Management Strategy Considering Carbon Quota Guided Demand Response [J]. Journal of Shanghai Jiao Tong University, 2023, 57(9): 1126-1136.
[9]	ZHANG Chenyu, MENG Shuai. Simulation Study of Reentry Dynamics of a Deep-Water Drilling Riser System Based on Model Predictive Control [J]. Journal of Shanghai Jiao Tong University, 2023, 57(11): 1389-1399.
[10]	YAO Laipeng (姚来鹏), HOU Baolin ∗(侯保林), LIU Xi (刘曦). Fast Smooth Second-Order Sliding Mode Control with Disturbance Observer for Automatic Shell Magazine [J]. J Shanghai Jiaotong Univ Sci, 2021, 26(6): 847-856.
[11]	WANG Jiaqi, GUO Jianguo, GUO Zongyi, ZHAO Bin. Sliding Mode Control of High Mach Number Aircraft Based on Disturbance Observer [J]. Air & Space Defense, 2021, 4(3): 85-91.
[12]	ZHANG Xiaoyu, ZHANG Peng, ZHENG Xin, NI Yuanhua. Terminal Angle Constraint Sliding Mode Guidance Law Design Based on Fixed-time Convergence [J]. Air & Space Defense, 2020, 3(3): 9-15.
[13]	ZHUANG Peng,FENG Zhengping,BI Anyuan,ZHENG Tianhai,PAN Wanjun,ZHAO Shuo. Depth Composite Control of Low Speed Underwater Vehicle Near Surface [J]. Journal of Shanghai Jiaotong University, 2019, 53(9): 1084-1090.
[14]	LI Donghui,GAO Feng. Improved Smith Predictive Decoupling Control Based on Disturbance Observer for Compression Refrigeration System [J]. Journal of Shanghai Jiaotong University, 2019, 53(5): 593-599.
[15]	YUE Caichenga (岳才成), CHEN Hongbina (陈红彬), QIAN Linfanga (钱林方), KONG Jianshoub (孔建寿). Adaptive Sliding-Mode Tracking Control for an Uncertain Nonlinear SISO Servo System with a Disturbance Observer [J]. Journal of Shanghai Jiao Tong University (Science), 2018, 23(3): 376-.

Model Predictive Control for Steering System of Water-Jet Propulsion

Model Predictive Control for Steering System of Water-Jet Propulsion

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 11

Related Articles 15

Recommended Articles

Metrics

Comments