高温熔盐止回阀受熔盐颗粒冲击的压力脉动响应

doi:10.1007/s12204-023-2601-3

J Shanghai Jiaotong Univ Sci ›› 2024, Vol. 29 ›› Issue (2): 271-279.doi: 10.1007/s12204-023-2601-3

高温熔盐止回阀受熔盐颗粒冲击的压力脉动响应

李树勋，沈恒云，刘斌才，胡迎港，马廷前

（兰州理工大学石油化工学院，兰州730050；机械工业泵及特殊阀门工程研究中心，兰州730050）

接受日期:2022-02-22 出版日期:2024-03-28 发布日期:2024-03-28

Pressure Pulse Response of High Temperature Molten Salt Check Valve Hit by Crystal Particles

LI Shuxun (李树勋), SHEN Hengyun^* (沈珩云), LIU Bincai (刘斌才),HU Yinggang (胡迎港), MA Tingqian (马廷前)

(School of Petrochemical Engineering, Lanzhou University of Technology, Lanzhou 730050, China; Machinery Industry Pump and Special Valve Engineering Research Center, Lanzhou 730050, China)

Accepted:2022-02-22 Online:2024-03-28 Published:2024-03-28

摘要/Abstract

摘要： 针对熔盐回路中介质结晶产生的颗粒诱发旋启式止回阀产生的流激振动问题，基于计算流体力学方法结合欧拉两相流模型，对典型开度为20%、60%和100%的阀内流场在严苛工况下，湍流过程中不同粒径的熔盐颗粒物冲击阀内件及其阀体内壁的强迫振动进行数值模拟研究，提取时域压力脉动信息，并进行统计学数据处理分析。分析典型开度下，熔盐结晶产生熔盐颗粒对阀内流动、压力脉动强度的影响规律。结果表明，熔盐的结晶对阀体的振动有严重影响，特别是在节流速率方面。压力脉动引起的阀门振动主要发生在较小的开度，同时，随着开度增大，压力脉冲阈值和变化趋势减小。

关键词: 熔盐阀，数值模拟，压力脉动，两相流，结晶冻堵

Abstract: In view of the problem that crystalline particles cause wall vibration at a low temperature, based on two-phase flow model, computational fluid dynamics is used to conduct the numerical simulation of internal flows when the valve openings are 20%, 60% and 100% respectively. The molten salt flow may be changed under strict conditions and produce forced vibration of the inner parts of molten salt particle shock valve body. Euler two-phase flow model is used for different molten salt sizes to extract temporal pressure pulse information and conduct statistical data processing analysis. The influence of the molten salt crystallization of molten salt particles on the flow and pressure pulse strength is analyzed. The results show that the crystallization of molten salt has a serious impact on the vibration of the valve body, especially in the throttle rate. The valve oscillation caused by the pressure pulsation mostly occurs from the small opening rate. As the opening increases, the pressure pulse threshold and its change trend decrease.

Key words: molten salt valve, numerical simulation, pressure pulsation, two-phase flow, crystal frozen blocking

中图分类号:

TH134

李树勋，沈恒云，刘斌才，胡迎港，马廷前. 高温熔盐止回阀受熔盐颗粒冲击的压力脉动响应[J]. J Shanghai Jiaotong Univ Sci, 2024, 29(2): 271-279.

LI Shuxun (李树勋), SHEN Hengyun^* (沈珩云), LIU Bincai (刘斌才),HU Yinggang (胡迎港), MA Tingqian (马廷前). Pressure Pulse Response of High Temperature Molten Salt Check Valve Hit by Crystal Particles[J]. J Shanghai Jiaotong Univ Sci, 2024, 29(2): 271-279.

参考文献

[1] MARTIN C, BAUER T, MüLLER-STEINHAGEN H. An experimental study of a non-eutectic mixture of KNO3 and NaNO3 with a melting range for thermal energy storage [J]. Applied Thermal Engineering, 2013, 56(1/2): 159-166.
[2] ZHAO Y, HONG H, JIN H, et al.. Thermodynamic mechanism for hybridization of moderate-temperature solar heat with conventional fossil-fired power plant [J]. Energy, 2017, 133: 832-842.
[3] RODRIGUEZ-GARCIA M M, ROJAS M E, P′EREZ M. Procedures for testing valves and pressure transducers with molten salt [J]. Applied Thermal Engineering, 2016, 101: 139-146.
[4] BONANOS A M, GEORGIOU M C, STOKOS K G, et al. Engineering aspects and thermal performance of molten salt transfer lines in solar power applications [J]. Applied Thermal Engineering, 2019, 154: 294-301.
[5] LI S X, SHEN H Y, ZHANG W N, et al. Cavitation characteristics and pressure pulsation response of piston type flow control valve [J]. Journal of Huazhong University of Science and Technology (Nature Science Edition), 2020, 48(12): 44-48 (in Chinese).
[6] QIAN J Y, WU J Y, GAO Z X, et al. Pilot pipe and damping orifice arrangements analysis of a pilotcontrol globe valve [J]. Journal of Fluids Engineering, 2020, 142(10): 101210.
[7] LI S, ZHU L, WANG W, et al. Analysis of thermal- fluid-structure coupling and resonance forecast for link butterfly valve under small opening [J]. Journal of Shanghai Jiaotong University (Science), 2019, 24(3): 341-350.
[8] DARBANDI T, RISBERG M, WESTERLUND L. CFD modeling of the forces in the wet scrubber acting on particulate matter released from biomass combustion [J]. Thermal Science and Engineering Progress, 2021, 25: 100997.
[9] GROSU Y, UDAYASHANKAR N, BONDARCHUK O, et al. Unexpected effect of nanoparticles doping on the corrosivity of molten nitrate salt for thermal energy storage [J]. Solar Energy Materials and Solar Cells, 2018, 178: 91-97.
[10] MA L, ZHANG C, WU Y, et al. Effect of flow rate and SiO2 nanoparticle on dynamic corrosion behavior of stainless steels in molten salt for thermal energy storage [J]. Corrosion Science, 2022, 194: 109952.
[11] KASPER R, DEPONTE H, MICHEL A, et al. Numerical investigation of the interaction between local flow structures and particulate fouling on structured heat transfer surfaces [J]. International Journal of Heat and Fluid Flow, 2018, 71: 68-79.
[12] WANG Z, LIU M. Semi-resolved CFD-DEM for thermal particulate flows with applications to fluidized beds [J]. International Journal of Heat and Mass Transfer, 2020, 159: 120150.
[13] HAN Z, XU Z, YU X. CFD modeling for prediction of particulate fouling of heat transfer surface in turbulent flow [J]. International Journal of Heat and Mass Transfer, 2019, 144: 118428.
[14] LI S X, HOU Y Z, LI L C. Dynamic characteristics of swing check valve based on dynamic mesh and UDF [J]. Applied Mechanics and Materials, 2013, 321/322/323/324: 86-89.
[15] ABUTAYEH M, PADILLA R V, LAKE M, et al. Effect of short cloud shading on the performance of parabolic trough solar power plants: Motorized vs manual valves [J]. Renewable Energy, 2019, 142: 330-344.
[16] WANG C Z. Study on characteristics of flow field and mechanism of particles passing through sieve under centrifugal coupled screening effect [D]. Xuzhou: China University of Mining and Technology, 2019 (in Chinese).
[17] CHENG W, GU B, SHAO C, et al. Hydraulic characteristics of molten salt pump transporting solid-liquid two-phase medium [J]. Nuclear Engineering and Design, 2017, 324: 220-230.
[18] WANG W Q, QIU Y, HE Y L, et al. Experimental study on the heat transfer performance of a moltensalt printed circuit heat exchanger with airfoil fins for concentrating solar power [J]. International Journal of Heat and Mass Transfer, 2019, 135: 837-846.

高温熔盐止回阀受熔盐颗粒冲击的压力脉动响应

Pressure Pulse Response of High Temperature Molten Salt Check Valve Hit by Crystal Particles

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价