A Novel BrakebyWire Unit and Control System for Electric Vehicle

Abstract

Abstract: Abstract： For the characteristics of full electric propulsion on electric vehicle, a novel brakebywire unit， called directdrive electrohydraulic brake unit， was designed to improve the braking performance of electric vehicles based on an electromagnetic linear actuator. A prototype was modified and completed based on a certain type of hydraulic brake unit after the structure and principle of this novel brake unit was described in detail. Then, a braking force controller and a power driver were established based on the digital signal processor TMS320F2812, and a doubleloop antidisturb algorithm was designed to regulate the braking force. The experiment results show that the response time of this brake unit is very short and the brake force is able to be accurately regulated, showing that this brake unit has a good application prospect.

Key words: Key words： electromagnetic linear actuator, directdrive electrohydraulic brake unit, digital signal processor, power circuit, electric vehicle

CLC Number:

U 463.51

GONG Xiaoxiang, CHANG Siqin, JIANG Lichen, LI Xiaopan. A Novel BrakebyWire Unit and Control System for Electric Vehicle[J]. Journal of Shanghai Jiao Tong University, 2016, 50(03): 395-400.

References

［1］MEN J L, WU B F, CHEN J. Comparisons of 4WS and BrakeFAS based on IMC for vehicle stability control ［J］. Journal of Mechanical Science and Technology, 2011, 25 (5):12651277. ［2］张小龙,冯能莲,张为公.基于车轮力直接测量ABS性能试验研究［J］.中国机械工程, 2008, 19(6):751755. ZHANG Xiaolong, FENG Nenglin, ZHANG Weigong. Experimental research on the ABS performance based on the wheel forces measured by roadway test［J］.China Mechanical Engineering, 2008, 19(6):751755. ［3］宋晓琳,冯广刚,杨济匡.汽车主动避撞系统的发展现状及趋势［J］.汽车工程,2009,30(4):285290. SONG Xiaolin, FENG Guanggang,YANG Jikuang. The current state and trends of automotive active collisionavoidance system［J］. Automotive Engineering, 2009,30 (4):285290. ［4］刘清河,孙泽昌.汽车线控制动系统研究［J］.机械与电子, 2007 (11): 2426. LIU Qinghe, SUN Zechang. Research of automotive BBW system［J］. Machinery & Electronics, 2007 (11): 2426. ［5］SUNDAR M, PLUNKETT D. Brakebywire, motivation and engineeringGM sequel［C］//SAE paper. USA:SAE, 2006: 2006013194. ［6］D'ALFIO N, MORGANDO A, SORNIOTTI A. Electrohydraulic brake systems: Design and test through hardwareintheloop simulation ［J］. Vehicle System Dynamics, 2006, 44(sup.1): 378392. ［7］LEE C F, MANZIE C. Adaptive brake torque variation compensation for an electromechanical brake ［J］. SAE International Journal of Passenger CarsElectronic and Electrical Systems, 2012, 5(2): 600606. ［8］HAN K, KIM M, HUH K. Modeling and control of an electronic wedge brake ［J］. Journal of Mechanical Engineering Science, 2012,226(10):24402455. ［9］常思勤,龚小祥,李小攀.一种用于线控制动系统的直驱电液制动单元［P］.中国:201110332564.1. 20111028. ［10］GUAN D, YANG X H, LIU G, et al. The Study of Electromechanical Brake Device Based on the Ball Screw ［J］. Applied Mechanics and Materials, 2012, 155: 509513. ［11］FOX J, ROBERTS R, BAIERWELT C, et al. Modeling and control of a single motor electronic wedge brake ［C］∥SAE Paper. USA:SAE, 2007: 2007010866. ［12］李志远,刘昭度,崔海峰,等.汽车ABS制动轮缸压力变化速率模型试验［J］.农业机械学报,2007,38(9):69. LI Zhiyuan, LIU Zhaodu, CUI Haifeng,et al. Experimental study on change rate model of brake pressure of ABS wheel cylinder［J］. Transactions of the Chinese Society of Agricultural Machinery, 2007,38(9):69. ［13］韩京清.自抗扰控制技术［J］.前沿科学,2007(1):2431. HAN Jingqing. Auto disturbances rejection control technique ［J］. Frontier Science,2007(1):2431. ［14］施昕昕.基于电磁直线执行器的运动控制技术研究［D］.南京:南京理工大学机械工程学院,2012. ［15］陈增强,孙明玮,杨瑞光.线性自抗扰控制器的稳定性研究［J］.自动化学报,2013,39(5):574580. CHEN ZengQiang, SUN MingWei, YANG RuiGuang. On the stability of linear active disturbance rejection control［J］. Acta Automatica Sinica, 2013,39(5):574580. ［16］余志生.汽车理论［M］.北京:机械工业出版社,2007. ［17］谭树梁.轻型汽车电子机械制动执行器及硬件在环试验台研究［D］.长春:吉林大学汽车工程学院,2008.

[1]	Peng Cheng, Chen Li, Fu Shenglai. Nonlinear Disturbance Observer of Clutch Slipping Torque for Multi-Mode Hybrid Electric Vehicles [J]. J Shanghai Jiaotong Univ Sci, 2026, 31(2): 420-427.
[2]	LIU Lin, YANG Siyu, HUANG Xianan, CHEN Yantao, XU Huashuai, WANG Lingling, JIANG Chuanwen. Data-Model Hybrid-Driven Simulation Method for Electric Vehicle Fleet Behavior [J]. Journal of Shanghai Jiao Tong University, 2026, 60(1): 51-60.
[3]	LIU Yongjiang, GUO Shan, JIA Junqing, LIU Xiaokai, CAI Wenchao, ZENG Long. Electric Vehicles Hierarchical Charging Method Considering Multiple Modes Coordination [J]. Journal of Shanghai Jiao Tong University, 2025, 59(9): 1304-1314.
[4]	HU Long, FANG Baling, FAN Feilong, CHEN Dawei, LI Xinxi, ZENG Run. Energy Interaction and Energy Storage Sharing Optimization Method for Users, Base Stations, and Charging Stations [J]. Journal of Shanghai Jiao Tong University, 2025, 59(7): 877-888.
[5]	WANG Guojun, WANG Liye, WANG Lifang, LIAO Chenglin. Electric Vehicle Charging Load Modeling Based on Influence Factor Analysis [J]. J Shanghai Jiaotong Univ Sci, 2025, 30(6): 1232-1241.
[6]	SUN Xin, JIANG Hailin, XIE Jingdong, WANG Simin, WANG Sen. Charging and Discharging Scheduling Mechanism of Electric Vehicles in Park Based on User Credit Index [J]. Journal of Shanghai Jiao Tong University, 2025, 59(2): 200-207.
[7]	PAN Yi, WANG Mingshen, MIAO Huiyu, YUAN Xiaodong, HAN Huachun. An Evolutionary Game Approach to Incentive Mechanism of Vehicle-to-Grid [J]. Journal of Shanghai Jiao Tong University, 2025, 59(11): 1637-1646.
[8]	HAN Yiming, HE Bin, YANG Bo, LI Jiale. Optimal Planning of Electric Vehicle Charging Stations Combined with Battery Energy Storage Systems Considering Driving Characteristics [J]. Journal of Shanghai Jiao Tong University, 2025, 59(11): 1720-1731.
[9]	BAI Wenchao, BAN Mingfei, SONG Meng, XIA Shiwei, LI Zhiyi, SONG Wenlong. Coordinate Scheduling Model of Electric Vehicle-Unmanned Aerial Vehicle Joint Rescue System [J]. Journal of Shanghai Jiao Tong University, 2024, 58(9): 1443-1453.
[10]	DENG Jiali (邓佳莉), HU Hao^∗ (胡昊), DAI Lei (戴磊). How Will Dynamic Charging Tariff Affect Electric Truck Fleet Operation: A Two-Stage Stochastic Model [J]. J Shanghai Jiaotong Univ Sci, 2024, 29(6): 1050-1062.
[11]	QIU Gefei, FENG Zehua, SHEN Fu, HE Chao, HE Honghui, LIU Kaiming. Dynamic Double-Layer Energy Management Strategy for Park Power Grid Considering Vehicle-to-Grid [J]. Journal of Shanghai Jiao Tong University, 2024, 58(6): 916-925.
[12]	SUN Yi, GE Mingyang, WANG Xianchun, BAO Huiyu, YANG Hongyue, YAO Tao. Multi-Region Optimal Scheduling Strategy for Electric Vehicles Considering Compensation Incentives [J]. Journal of Shanghai Jiao Tong University, 2024, 58(5): 636-646.
[13]	ZHANG Cheng, KUANG Yu, CHEN Wenxing, ZHENG Yang. Low Carbon Economy Optimization of Integrated Energy System Considering Electric Vehicle Charging Mode and Multi-Energy Coupling [J]. Journal of Shanghai Jiao Tong University, 2024, 58(5): 669-681.
[14]	WANG Jing, XING Haijun, WANG Huaxin, PENG Sijia. Optimal Scheduling of Integrated Energy System Considering Integration of Electric Vehicles and Load Aggregators [J]. Journal of Shanghai Jiao Tong University, 2023, 57(7): 814-823.
[15]	BAO Lewen (鲍乐雯), MIAO Rui, ∗ (苗瑞), CHEN Zhihua (陈志华), ZHANG Bo (张博), GUO Peng (郭鹏), MA Yuze (马宇泽). Travel Intention of Electric Vehicle Sharing based on Theory of Multiple Motivations [J]. J Shanghai Jiaotong Univ Sci, 2023, 28(1): 1-9.