CO2微通道气冷器的流场分解模拟及实验验证

摘要/Abstract

摘要： 为了研究CO₂流量分配不均匀度对气冷器流动特性和传热特性的影响，建立了跨临界CO₂制冷系统的微通道气冷器分解模型. 实验结果表明：随着CO₂制冷剂质量流量由110 kg/h增大到470 kg/h，扁平管内最大流量不均匀度由97% 降低到18%,流量是影响不均匀度的重要因素；流量分配不均度对CO2微通道气冷器的流动特性影响明显，而对传热特性影响较小. 比较了不同工况下相应的模拟结果与实验数据,平均换热系数误差为4.82%~38.25%，摩擦系数误差为6.09%~26.65%.

关键词: , 分解数值模拟, 微通道气冷器, 二氧化碳跨临界循环, 不均匀分配

Abstract: 摘要：关键词： In order to investigate the effect of CO2 maldistribution in microchannel on the flow and heat transfer characteristics of gas cooler, decomposing numerical model of microchannel gas cooler in transcritical CO2 system was constructed and experimentally verified. The results show that the maximum flow rate nonuniformity decreases from 97% to 18% as total inlet flow rate of CO2 increases from 110 kg/h to 470 kg/h, meaning that the flow rate is the critical factor of maldistribution. The maldistribution of refrigerant flux has a significant effect on the flow characteristics of microchannel gas cooler. While to the heat transfer characteristics, its effect is not obvious. The numerical results were compared with the experimental data under different running conditions. The inaccuracy of average heat transfer coefficient ranges from 482% to 3825%, and the inaccuracy of friction coefficient ranges from 6.09% to 26.65%.

Key words: decomposing numerical simulation, microchannel gas cooler, carbon dioxide transcritical cycle, maldistribution

中图分类号:

TB 657.5

巫江虹, 李程, 杨兆光. CO₂微通道气冷器的流场分解模拟及实验验证[J]. 上海交通大学学报（自然版）, 2012, 46(03): 474-479.

WU Jiang-Hong, LI Cheng, YANG Zhao-Guang. Decomposing Numerical Simulation and Experimental Verification of Carbon Dioxide Micro-channel Gas Cooler[J]. Journal of Shanghai Jiaotong University, 2012, 46(03): 474-479.

参考文献

［1］Jabardo J M S, Mamani W G, Ianella M R. Modeling and experimental evaluation of an automotive air conditioning system with a variable capacity compressor［J］. International Journal of Refrigeration, 2002, 25(8):11571172.
［2］Peles Y P, Haber S. A steady state, one dimensional, model for boiling two phase flow in triangular microchannel［J］. International Journal of Multiphase Flow, 2000, 26(7):10951115.
［3］Chung K, Lee K S, Cha D J. A numerical study of flow distribution effect on a parallel flow heat exchanger［J］. KSME International Journal, 2001, 15(11):15631571.
［4］饶政华, 廖胜明. CO2微通道气体冷却器的数值仿真与性能优化［J］.化工学报， 2005, 56(9):17211726.
RAO Zhenghua, LIAO Shengming. Numerical simulation and performance optimization of carbon dioxide microchannel gas cooler［J］. Journal of Chemical Industry and Engineering, 2005, 56(9):17211726.
［5］陆平, 陈江平, 陈芝久. 微通道平行流气冷器流量分配的数值模拟［J］. 应用科学学报， 2007, 25(3):317322.
LU Ping, CHEN Jiangping, CHEN Zhijiu. Computational fluid dynamics simulation of flow distribution in a gas cooler with microchannel parallel flow［J］. Journal of Applied Sciences, 2007, 25(3):317322.
［6］黄冬平, 梁贞潜, 丁国良,等. 基于模型的CO2微通道气体冷却器性能分析［J］.化工学报， 2002, 53(8):832836.
HUANG Dongping, LIANG Zhenqian, DING Guoliang, et al. Modeling and performance analysis of carbon dioxide microchannel gas cooler［J］. Journal of Chemical Industry and Engineering, 2002, 53(8):832836.
［7］梁贞潜, 丁国良, 张春路, 等. 二氧化碳汽车空调器仿真与优化［J］.上海交通大学学报， 2002, 36(10):13971399.
LIANG Zhenqian, DING Guoliang, ZHANG Chunlu, et al. Simulation and optimization of carbon dioxide automobile air conditioner［J］. Journal of Shanghai Jiaotong University, 2002, 36(10):13971399.
［8］Uddin M F, Nurujjaman M, Assi C. Joint scheduling and spectrum allocation in wireless networks with frequencyagile radios［C］// Proc 9th International Conference on AdHoc Networks and Wireless. Edmonton, Canada: University of Alberta, 2010: 95108.
［9］Xue R, Zhao D F, Zhu T L. An improved method for the convergence of iterative detection in turboCPM system［C］// Proc 5th International Conference on Wireless Communications, Networking and Mobile Computing. Beijing, China: IEEE Press, 2009: 445449.
［10］Mclinden M, Klein S A, Lemmon E W, et al. Thermodynamic and transport properties of refrigerant and refrigerant mixtureREFPROP［R］. Version 601. National Institute of Standards and Technology, USA, 1998.
［11］李程, 巫江虹, 崔晓龙, 等. CO2微通道气体冷却器压降与传热特性研究［J］.西安交通大学学报， 2010, 44(9):4853.
LI Cheng, WU Jianghong, CUI Xiaolong, et al. CO2 pressure drop and heat transfer characteristics in microchannel gas cooler［J］. Journal of Xi’an Jiaotong University, 2010, 44(9):4853.
［12］于绿，郝柏林. 相变与临界现象［M］.北京: 科学出版社,1992.
［13］阙雄才, 陈江平. 汽车空调实用技术［M］.北京: 机械工业出版社,2003.
［14］Liao S M, Zhao T S. Measurement of heat transfer coefficient from supercritical carbon dioxide flowing in horizontal mini/micro channels［J］. Journal of Heat TransferTransactions of the ASME, 2002, 124(3):413420.
［15］Yoon S H, Kim J H, Hwang Y W, et al. Heat transfer and pressure drop characteristics during the intube cooling process of carbon dioxide in the supercritical region［J］. International Journal of Refrigeration, 2003, 26(8):857864.
［16］Dang C, Hihara E. Intube cooling heat transfer of supercritical carbon dioxide. Part 1. Experimental measurement［J］. International Journal of Refrigeration, 2004, 27(7):736747.
［17］Huai X L, Koyama S, Zhao T S. An experimental study of flow and heat transfer of supercritical carbon dioxide in multiport mini channels under cooling conditions［J］. Chemical Engineering Science, 2005, 60(12):33373345.
［18］Son C H, Park S J. An experimental study on heat transfer and pressure drop characteristics of carbon dioxide during gas cooling process in a horizontal tube［J］. International Journal of Refrigeration, 2006, 29(4):539546.
［19］Huai X, Koyama S. Heat transfer characteristics of supercritical CO2 flow in smallchanneled structures［J］. Experimental Heat Transfer, 2007, 20(1):1933.

[1]	王聚团, 戚晓宁, 黄志明. 水下生产管汇测试技术及其改进研究[J]. 海洋工程装备与技术, 2022, 9(2): 43-49.
[2]	袁振钦, 邹科, 孙亚峰, 刘刚, 屈衍, 李居跃. 基于时域分析法的动态电缆疲劳分析[J]. 海洋工程装备与技术, 2022, 9(2): 50-55.
[3]	王娟, 杨明旺, 郑茂尧, 刘凌云, 赵立君. 高强钢在大型半潜式平台组块建造中的应用[J]. 海洋工程装备与技术, 2022, 9(1): 27-31.
[4]	陈欣, 赵晓磊, 王立坤, 肖德明, 张腾月. 深水大型吸力锚建造技术研究[J]. 海洋工程装备与技术, 2022, 9(1): 32-36.
[5]	尹彦坤, 易涤非. 半潜式生产平台船体结构关键节点工程临界评估[J]. 海洋工程装备与技术, 2022, 9(1): 52-57.
[6]	ZHANG Shengfa (张胜发), TANG Na (唐纳), SHEN Guofeng (沈国峰), WANG Han (王悍), QIAO Shan (乔杉). Universal Software Architecture of Magnetic Resonance-Guided Focused Ultrasound Surgery System and Experimental Study[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(4): 471-481.
[7]	MA Qunsheng (马群圣), CEN Xingxing (岑星星), YUAN Junyi (袁骏毅), HOU Xumin (侯旭敏). Word Embedding Bootstrapped Deep Active Learning Method to Information Extraction on Chinese Electronic Medical Record[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(4): 494-502.
[8]	安庆升, 孙立东, 武秋生. 碳纤维增强复合材料发射筒设计研究[J]. 空天防御, 2021, 4(2): 13-.
[9]	KONG Xiangqiang (孔祥强), MENG Xiangxi (孟祥熙), LI Jianbo (李见波), SHANG Yanping (尚燕平), CUI Fulin (崔福林) . Comparative Study on Two-Stage Absorption Refrigeration Systems with Different Working Pairs[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(2): 155-162.
[10]	ZHUANG Weimin (庄蔚敏), WANG Pengyue (王鹏跃), AO Wenhong (熬文宏), CHEN Gang (陈刚) . Experiment and Simulation of Impact Response of Woven CFRP Laminates with Different Stacking Angles[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(2): 218-230.
[11]	ZHOU Xuhui (周旭辉), ZHANG Wenguang (张文光), XIE Jie (谢颉). Effects of Micro-Milling and Laser Engraving on Processing Quality and Implantation Mechanics of PEG-Dexamethasone Coated Neural Probe[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(1): 1-9.
[12]	HUANG Ningning (黄宁宁), MA Yixin (马艺馨), ZHANG Mingzhu (张明珠), GE Hao (葛浩), WU Huawei (吴华伟). Finite Element Modeling of Human Thorax Based on MRI Images for EIT Image Reconstruction[J]. J Shanghai Jiaotong Univ Sci, 2021, 26(1): 33-39.
[13]	WANG Xianjin, GAO Xu, YU Kuigang . Fixture Locating Modelling and Optimization Research of Aluminum Alloy Sidewall in a High-Speed Train Body[J]. J Shanghai Jiaotong Univ Sci, 2020, 25(6): 706-713.
[14]	QIAO Xing, MA Dan, YAO Xuliang, FENG Baolin. Stability and Numerical Analysis of a Standby System[J]. J Shanghai Jiaotong Univ Sci, 2020, 25(6): 769-778.
[15]	WU Jin, MIN Yu, YANG Xiaodie, MA Simin . Micro-Expression Recognition Algorithm Based on Information Entropy Feature[J]. Journal of Shanghai Jiao Tong University(Science), 2020, 25(5): 589-599.

CO₂微通道气冷器的流场分解模拟及实验验证

Decomposing Numerical Simulation and Experimental Verification of Carbon Dioxide Micro-channel Gas Cooler

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价