Modeling and Control of the Pulley Buffer System of
Arresting Cable for Shipboard Aircraft Based on
Magneto-Rheological Fluid

doi:10.1007/s12204-012-1327-4

上海交通大学学报（英文版） ›› 2012, Vol. 17 ›› Issue (5): 573-578.doi: 10.1007/s12204-012-1327-4

Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid

FU Li1 (傅莉), WEI Ying2*(魏颖), ZHOU Yan-kai1 (周彦凯), CHENG Tao1 (程涛)

(1. Faculty of Aerospace Engineering, Shenyang Aerospace University, Shenyang 110136, China; 2. Institute of Artificial Intelligence & Robotics, Northeastern University, Shenyang 110004, China)

出版日期:2012-10-30 发布日期:2012-11-16
通讯作者: WEI Ying2*(魏颖) E-mail:weiying@ise.neu.edu.cn

Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid

FU Li1 (傅莉), WEI Ying2*(魏颖), ZHOU Yan-kai1 (周彦凯), CHENG Tao1 (程涛)

(1. Faculty of Aerospace Engineering, Shenyang Aerospace University, Shenyang 110136, China; 2. Institute of Artificial Intelligence & Robotics, Northeastern University, Shenyang 110004, China)

Online:2012-10-30 Published:2012-11-16
Contact: WEI Ying2*(魏颖) E-mail:weiying@ise.neu.edu.cn

摘要/Abstract

摘要： Taking the MK7-3 of USA hydraulic buffer arresting device as the research subject, the dynamical model for the shipboard aircraft arresting system is established, and the magneto-rheological (MR) damper is applied to pulley shock absorbers for shipboard aircraft block system. Due to the effect of the MR damper has not been known completely and so far MR damper model has not been defined, we use a set of characteristic test of the MR damper, through the process of parameters identification, to establish the dynamical model for the MR damper based on the Bingham plastic model. Then, the fuzzy control rules are designed, the buffer control for the pulley buffer of shipboard aircrafts is completed in touchdown moment based on MR technology. Compared with blocking device of hydraulic pulley buffer in the same condition, the simulations results show that the proposed MR pulley buffer can effectively recognize the impact energy for shipboard block system and reduce the pull peak of arresting cable. It improves significantly safety during landing of the air vehicles and lowers the risk of accidents.

关键词: magneto-rheological fluid (MRF), shipboard aircraft, pulley buffer, parameter identification, fuzzy control

Abstract: Taking the MK7-3 of USA hydraulic buffer arresting device as the research subject, the dynamical model for the shipboard aircraft arresting system is established, and the magneto-rheological (MR) damper is applied to pulley shock absorbers for shipboard aircraft block system. Due to the effect of the MR damper has not been known completely and so far MR damper model has not been defined, we use a set of characteristic test of the MR damper, through the process of parameters identification, to establish the dynamical model for the MR damper based on the Bingham plastic model. Then, the fuzzy control rules are designed, the buffer control for the pulley buffer of shipboard aircrafts is completed in touchdown moment based on MR technology. Compared with blocking device of hydraulic pulley buffer in the same condition, the simulations results show that the proposed MR pulley buffer can effectively recognize the impact energy for shipboard block system and reduce the pull peak of arresting cable. It improves significantly safety during landing of the air vehicles and lowers the risk of accidents.

Key words: magneto-rheological fluid (MRF), shipboard aircraft, pulley buffer, parameter identification, fuzzy control

中图分类号:

TP 273

FU Li1 (傅莉), WEI Ying2*(魏颖), ZHOU Yan-kai1 (周彦凯), CHENG Tao1 (程涛). Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid[J]. 上海交通大学学报（英文版）, 2012, 17(5): 573-578.

FU Li1 (傅莉), WEI Ying2*(魏颖), ZHOU Yan-kai1 (周彦凯), CHENG Tao1 (程涛). Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid[J]. Journal of shanghai Jiaotong University (Science), 2012, 17(5): 573-578.

参考文献

[1] Li Jie, Yu Chuan. The aircraft carrier aircraft carrier landing equipment [J]. Modern Military, 2006(10): 56-58 (in Chinese).

[2] MIL-A-8863B(AS), Airplane strength and rigidity ground loads for navy acquired airplanes [S].

[3] MIL-A-8863C(AS), Airplane strength and rigidity ground loads for navy acquired airplanes [S].

[4] MIL-A-18717C(AS), Arresting hook installations, aircraft[S].

[5] Department of the Air Force. Guide to mobile aircraft arresting system installation [M].Washington DC: Secretary of the Air Force Washington DC, 2000: 1-182.

[6] Liu Gang, Nie Hong. Dynamics analysis for aircraft arresting based on absorbing aircraft kinetic energy [J].China Mechanical Engineering, 2009, 20(4): 450-454(in Chinese).

[7] Jankowski L, Mikulowski G. Adaptive landing gearOptimum control strategy and improvement potential[C]// Conference on Noise and Vibration Engineering.Leuven, Belgium: International Security Management Association, 2006: 1-15.

[8] Hu W, Werely N M. Magneto-rheological fluid and elastomeric lag damper for helicopter stability augmentation [J]. International Journal of Modern Physics B, 2005, 19(7): 1471-1477.

[9] Ahmadian M, Appleton R J, Norris J A. Designing magneto-rheological dampers in a fire out-ofbattery recoil system [J]. IEEE Transactions on Magnetics,2003, 39(1): 480-485.

[10] Mikutowski G M. Adaptive impact absorbers based on magnetorheological fluids [D]. Warsaw, Poland:Smart Technology Centre Institute of Fundamental Technological Research Polish Academy of Sciences,2008.

[11] Duan Yuan-feng, Ni Yi-qing, Ko Jan-ming, et al. Design of MR dampers for open-loop vibration control of stay cables on cable supported structures [J] . Spatial Structures, 2007, 13(2): 58-64.

[12] Karakas E S, Gordaninejad F, Evrensel C A, et al. Control of a quarter HMMWV suspension system using a magneto-rheological fluid damper [C]// Proceedings of the International Society for Optical Engineering. Bellingham, USA: the International Society for Optical Engineering, 2004: 204-213.

[13] Fu Li, Xie Hua-long, Xu Xin-he. The modeling of magnetorheological fluids in advanced intelligent artificial limb [J]. Machine Tool & Hydraulics, 2009, 37(10):15-18 (in Chinese).

[14] Yang G, Spencer B F, Jung H J, et al. Dynamicmodeling of large-scale magnetorheological damper systems for civil engineering applications [J]. Journal of Engineering Mechanics, 2004, 130(9): 1107-1114.

Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid

Modeling and Control of the Pulley Buffer System of Arresting Cable for Shipboard Aircraft Based on Magneto-Rheological Fluid

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	YING Si-bin1* (应思斌), GE Tong1 (葛彤), AI Jian-liang2 (艾剑良). H∞ Parameter Identification and H2 Feedback Control Synthesizing for Inflight Aircraft Icing[J]. 上海交通大学学报（英文版）, 2013, 18(3): 317-325.
[2]	FU Li1* (傅莉), LIN Li-ping1 (林丽平), XU Xin-he2 (徐心和). Research on Modeling and Fuzzy Control of Magneto-Rheological Intelligent Buffer System for Impact Load[J]. 上海交通大学学报（英文版）, 2012, 17(5): 567-572.
[3]	GUO Hong-che1,2 (郭洪澈), QIU Tian-yu3 (邱天雨), JIANG Jiu-chun1 (姜久春). Design of Fuzzy Controller for Direct Drive Wind Turbines[J]. 上海交通大学学报（英文版）, 2012, 17(2): 209-214.