Direct Image Correction Algorithm for PIV Measurement of Flowfield within Circular Tube

Abstract

Abstract: A direct image correction algorithm based on the optical principle was developed to solve flowfield distortion of particle image velocimetry(PIV) measurement within circular tube. Without the restriction of liquid saturation temperature, this method can be applied for the synchronous correction of coordinate and velocity vector, and can correctly recover the image distortion in the vicinity of tube wall. In addition, this method requires no accessorial device. A computer code was developed based on Fortran language, which can be easily applied to other cases as long as changing the relevant input parameters. The method was validated by using a uniform square grid with the max deviation of 3%. And this method can provide a satisfactory correction result for the PIV experiment of cryogenic gasliquid two phase flow.

Key words: particle image velocimetry (PIV), image distortion, direct correction, circular tube, cryogenic liquid

CLC Number:

O 359.1

LIU Yi-Peng, HU Xue-Yu, CHEN Jia-Luo, WANG Ping-Yang, DU Chao-Hui. Direct Image Correction Algorithm for PIV Measurement of Flowfield within Circular Tube[J]. Journal of Shanghai Jiaotong University, 2013, 47(04): 525-532.

References

［1］van Hout R, Gulitski A, Barnea D, et al. Experimental investigation of the velocity field induced by a Taylor bubble rising in stagnant water ［J］. International Journal of Multiphase Flow, 2002, 28:579596.
［2］Sousa R G, Riethmuller M L, Pinto A M F R, et al. Flow around individual Taylor bubbles rising in stagnant polyacrylamide (PAA) solutions ［J］. Journal of NonNewtonian Fluid Mechanics, 2006, 135:1631.
［3］Polonsky S, Shemer L, Barnea D. The relation between the Taylor bubble motion and the velocity field ahead of it ［J］. International Journal of Multiphase Flow, 1999, 25: 957975.
［4］Benjamin J W, Haydee C D, Ronald J. Optical contouring of an acrylic surface for nonintrusive diagnostics in pipeflow investigations ［J］. Experiments in Fluids, 2008, 45: 95109.
［5］胡学羽, 刘亦鹏, 王平阳, 等. 倾斜管中低温气液两相流弹状气泡生成位置的实验研究［J］. 上海交通大学学报, 2012, 46(2): 306311.
HU Xueyu, LIU Yipeng, WANG Pingyang, et al. Experimental study on initial position of taylor bubbles of cryogenic twophase slug flow in inclined pipes ［J］. Journal of Shanghai Jiaotong University, 2012, 46(2): 306311.
［6］李如意, 黄为民. 柱状曲面容器内粒子图像测速中径向畸变校正方法［J］. 上海理工大学学报, 2008, 30(4): 315318.
LI Ruyi, HUANG Weimin. Method of radial distortion calibration for PIV measurement in a cylinder container with arbitrary curveshaped ［J］. Journal of University of Shanghai for Science and Technology, 2008, 30(4): 315318.
［7］Liu Y P, Wang P Y, Hu X Y, et al. Visualization research on characteristics of the cryogenic slug flow in vertical and inclined tubes ［J］. The Canadian Journal of Chemical Engineering, 2012, 90(6): 15881601.

[1]	CAO Taichun, WU Gang, KONG Xiangyi, YU Dongwei, WU Lin, ZHANG Dayong. Influence of Convection Heat Transfer on Circular Tube Structure of Polar Marine Engineering Equipment [J]. Journal of Shanghai Jiao Tong University, 2023, 57(1): 17-23.
[2]	ZHANG Xiaohui (张晓慧), GU Xiechong (顾解忡), MA Ning (马宁), WANG Yifan (王一凡), WU Zeren (吴泽仁). Experimental Investigation into the Effect of Roll Amplitude on Roll Damping [J]. Journal of Shanghai Jiao Tong University (Science), 2019, 24(6): 732-738.
[3]	XU Hongchang (徐宏昌), LIU Shuangzhai (刘双寨), PAN Haoxing (潘浩星). Spray Characteristics with High-Speed Tomographic Particle Image Velocimetry Under Non-Flash and Flash Boiling Conditions [J]. Journal of Shanghai Jiao Tong University (Science), 2019, 24(5): 591-596.
[4]	ZHAO Liang,ZHANG Wei,HE Zhiguo,TAN Liming,JIANG Houshuo. The Process of Mass Transport for a Buoyant Plume in Linearly Stratified Environment [J]. Journal of Shanghai Jiaotong University, 2019, 53(4): 473-479.
[5]	ZHU Rui,LI Shang,CHEN Ziyu,LIU Jinsheng,BAO Feng,LIU Zhirong. Flow Field Dynamic Characteristics of Slit Cylinders [J]. Journal of Shanghai Jiaotong University, 2019, 53(10): 1238-1248.
[6]	LV Yafei,ZHAO Liang,HE Zhiguo,LIN Yingtien,YUAN Yeping,HU Peng. Impacts of Obstacle on Gravity Currents Propagating Along a Flat Bed [J]. Journal of Shanghai Jiao Tong University, 2018, 52(8): 946-953.
[7]	GE Bing* (葛冰), ZANG Shu-sheng (臧述升), GUO Pei-qing (郭培卿). Experimental Study on Flow Structure of a Swirling Non-Premixed Syngas Flame [J]. Journal of shanghai Jiaotong University (Science), 2013, 18(1): 92-100.
[8]	XIE Long-1, JIN Si-Yu-1, 2 , YU Jian-Guo-1, WANG Yu-Zhang-1. PIV Analysis of Inner Flow Field in 90° Bending Duct of Circular-Section with Fore-End Valve [J]. Journal of Shanghai Jiaotong University, 2011, 45(09): 1395-1399.