上海交通大学学报

上海交通大学学报 ›› 2013, Vol. 47 ›› Issue (06): 867-871.doi: 10.16183/j.cnki.jsjtu.2013.06.004

所属专题： 王建华教授学报发文专辑

• • 上一篇    下一篇

基于注浆压力控制的混凝土顶管施工微扰动机理

丛茂强(), 陈锦剑, 王建华()   

  1. 上海交通大学土木工程系，上海 　200240
  • 收稿日期:2012-12-05 出版日期:2013-06-01 发布日期:2013-06-28
  • 作者简介:丛茂强（1987-)，男，辽宁瓦房店市人，硕士生，研究方向：岩土工程数值分析．E-mail:congmq@yahoo.com.cn.|王建华（联系人），男，教授，博士生导师，电话（Tel.):021-34207002;E-mail:wjh417@sjtu.edu.cn.
  • 基金资助:
    国家自然科学基金(41172251)

Micro Disturbance Mechanism of Concrete Pipe-jacking with Slurry Pressure Control

CONG Mao-qiang(), CHEN Jin-jian, WANG Jian-hua()   

  1. Department of Civil Engineering, Shanghai Jiaotong University, Shanghai 200240, China
  • Received:2012-12-05 Online:2013-06-01 Published:2013-06-28

RichHTML

12

PDF (PC)

1235

摘要：

为了研究顶管施工过程中注浆压力对控制土体变形的作用，建立有限元模型对注浆压力作用进行理论分析．通过对比实测数据与有限元结果，讨论了不同工况对孔隙水压力与土体变形的影响．分析了在不同注浆压力作用下，顶管周围土体的扰动情况，在此基础上提出了衡量土体受扰动程度的孔隙水压力变化率概念．结合土体变形状况与扰动分析结果，建议在实际工程中将注浆压力控制在管顶上覆土压力值的1.1倍，按此原则设定的注浆压力对周围环境影响较小，该研究结果可供今后类似顶管施工参考．

关键词: 混凝土顶管, 注浆压力, 孔隙水压力变化率, 微扰动, 有限元

Abstract:

A finite element model for theoretical analysis was established to study the effect of slurry pressure on soil deformation control during pipe-jacking construction. Based on the comparison of measured data and finite element results, the influences of pore pressure and soil deformation during the construction process were discussed. The soil disturbance around pipe-jacking with different slurry pressures was analyzed, based on which the concept of pore pressure change rate was proposed. Taking the results of soil deformation and disturbance analysis into consideration, it is suggested that in practical engineering, the slurry pressure should be 1.1 times the overlying earth pressure, which has less impacts on the surrounding environment. This conclusion can provide reference for future similar pipe-jacking constructions.

Key words: concrete pipe-jacking, slurry pressure, pore pressure change ratio, micro disturbance, finite element

中图分类号: