Journal of Shanghai Jiao Tong University

Journal of Shanghai Jiaotong University >

2023 , Vol. 57 >Issue 1: 17 - 23

DOI: https://doi.org/10.16183/j.cnki.jsjtu.2021.205

Naval Architecture, Ocean and Civil Engineering

Influence of Convection Heat Transfer on Circular Tube Structure of Polar Marine Engineering Equipment

Expand
  • 1. College of Marine Science and Technology, Dalian University of Technology, Panjin 124221, Liaoning, China
    2. Faculty of Vehicle Engineering and Mechanics, Dalian University of Technology, Dalian 116023, Liaoning, China
    3. Marine Design and Research Institute of China, Shanghai 200021, China

Received date: 2021-06-11

  Revised date: 2021-09-02

  Online published: 2022-08-02

Fold

Abstract

Electric heat tracing is often used for cold protection in polar ocean engineering equipment. Heat balance is the key problem of convective heat transfer. In this paper, the circular tube structure is taken as the research object. Numerical simulations using Fluent and model experiment are conducted to analyze the change of the convective heat transfer coefficient of the circular tube component under the polar environment with a wind speed range of 0—40 m/s and a temperature range of -40—0 ℃. Based on the numerical simulation data, the prediction model of the convective heat transfer coefficient of the electric heating tube is obtained. The results show that the convective heat transfer coefficient increases with the increase of wind speed and the decrease of temperature. When the temperature is below -30 ℃, or when the wind speed is greater than 25 m/s and the temperature is lower than -20 ℃, the influence of temperature on the convective heat transfer coefficient increases. The rationality of the model is verified by experimental test.

Key words： polar region; circular tube component; convective heat transfer; numerical simulation; experimental test

Cite this article

CAO Taichun, WU Gang, KONG Xiangyi, YU Dongwei, WU Lin, ZHANG Dayong . Influence of Convection Heat Transfer on Circular Tube Structure of Polar Marine Engineering Equipment[J]. Journal of Shanghai Jiaotong University, 2023 , 57(1) : 17 -23 . DOI: 10.16183/j.cnki.jsjtu.2021.205

References

[1] 沈杰, 白旭. 基于Fluent和FENSAP-ICE的极区海洋平台甲板结构结冰数值模拟[J]. 极地研究, 2020, 32(2): 177-183.
[1] SHEN Jie, BAI Xu. Numerical simulations of deck structure icing on polar offshore platforms based on fluent and fensap-ice[J]. Chinese Journal of Polar Research, 2020, 32(2): 177-183.
[2] 陆煊, 崔玫, 曹洪波, 等. 船舶防冻除冰技术现状与发展[J]. 船海工程, 2016, 45(2): 37-39.
[2] LU Xuan, CUI Mei, CAO Hongbo, et al. Present situation and development of de-icing and prevent frostbite technology of ships[J]. Ship & Ocean Engineering, 2016, 45(2): 37-39.
[3] ROEDER W, BAEN P, SEITZ R. Electric trace heat design methods for de-icing and anti-icing of vessels, support equipment and infrastructure in the arctic[C]//OCEANS 2017-Anchorage. Anchorage, AK, USA: IEEE, 2017: 1-7.
[4] AL-MDALLAL Q M, MAHFOUZ F M. Heat transfer from a heated non-rotating cylinder performing circular motion in a uniform stream[J]. International Journal of Heat and Mass Transfer, 2017, 112: 147-157.
[5] 周柏男. 横掠圆管和非圆管对流换热的数值分析[D]. 上海: 上海理工大学, 2018.
[5] ZHOU Bonan. The numerical analysis of convercation transfer across cylinders and non-circular tubes[D]. Shanghai: University of Shanghai for Science & Technology, 2018.
[6] IKHTIAR U, MANZOOR S, SHEIKH N A, et al. Free stream flow and forced convection heat transfer around a rotating circular cylinder subjected to a single gust impulse[J]. International Journal of Heat and Mass Transfer, 2016, 99: 851-861.
[7] WAN P X, HAN X S, MAO J K. Very Large Eddy Simulation of turbulent flow and heat transfer for single cylinder and cylindrical pin matrix[J]. Applied Thermal Engineering, 2020, 169: 114972.
[8] 李晓辰. 低温海水外掠圆管流动与换热规律研究[D]. 青岛: 中国石油大学(华东), 2017.
[8] LI Xiaochen. Study on convective heat transfer of hypothermic seawater flow across a tube[D]. Qingdao: China University of Petroleum (East China), 2017.
[9] CHURCHILL S W, BERNSTEIN M. A correlating equation for forced convection from gases and liquids to a circular cylinder in crossflow[J]. Journal of Heat Transfer, 1977, 99(2): 300-306.
[10] DHIMAN S K, KUMAR A, PRASAD J K. Unsteady computation of flow field and convective heat transfer over tandem cylinders at subcritical Reynolds numbers[J]. Journal of Mechanical Science and Technology, 2017, 31(3): 1241-1257.
[11] Guide for building and classing vessels intended for navigation in polar waters[S]. New York: ABS, 2008.
[12] INCROPERA F P, DEWITT D P. Fundamentals of heat and mass transfer[M]. 5th ed. New York: John Wiley & Sons, 2002: 389-395.
Options
Outlines

/

〈 〉