上海交通大学学报

上海交通大学学报（自然版） ›› 2015, Vol. 49 ›› Issue (07): 1067-1074.

• 交通运输 • 上一篇    

复合地层泥水盾构开挖面失稳破坏宏微观机理

胡欣雨，刘安洋   

  1. (上海应用技术学院 城市建设与安全工程学院，上海 201418)
  • 收稿日期:2013-09-30
  • 基金资助:

    国家自然科学基金（51108268）资助项目

Face Failure Mechanism for Slurry ShieldDriven Tunnel in layered Ground Condition — Coupling Macroscopic and Microscopic Aspect

HU Xinyu1,LIU Anyang1   

  1. (College of Urban Construction and Safety Engineering, Shanghai Institute of Technology, Shanghai 201418, China)
  • Received:2013-09-30

摘要：

摘要：  针对复合地层泥水盾构开挖面稳定性问题，采用试验研究和数值仿真分析相结合的方法，并结合宏观及微观研究手段，对泥水盾构施工过程中周围土体力学特性及地层变位，进行了定量分析，揭示了该地层条件开挖面的失稳破坏模式.在此基础上建立了完善的开挖面稳定性三维解析方法，主要得到以下结论：对于常见上软下硬复合地层情况，低应力水平条件下泥浆的渗入能在一定程度上提高土体的强度，减缓侧向变形的发展，因此，有效泥浆支护压力宜控制在较小的区间取值，且不宜过大，并应充分利用盾构本体正面挡板来保持地层的稳定；上软下硬复合地层中开挖面失稳破坏模式与砂性土地层的失稳破坏模式相似，即表现为开挖面前方为楔形体，破坏区域顶部为烟囱状，最大沉降量发生在开挖面前方顶部附近.

关键词: 泥水盾构, 复合地层, 泥浆压力, 失稳破坏模式

Abstract:

Abstract： The face stability mechanism for slurry shield under the layered ground condition is of great significance. During the process of the shield tunnelling, the original structure and the strength of the soil around the face will be changed due to the slurry gradual infiltration into the excavation face. Thus, in order to connect and quantify the relationship between the mechanical property and the microscopic structure, the triaxial experimental tests coupled with the numerical simulation method for evaluating the tunnellinginduced ground movement were introduced, Then, based on the actual geometry of the failure mechanism in clay, a modified wedge model with its corresponding analytical solution for the critical face support pressure was presented. For the layered ground condition, it is recommended that the slurry support pressure should be controlled to a relatively low level due to the softening characteristic of clay soil, and it is the pressure produced by the shield cutter bits and transferred to the excavation face contributes to face stabilization. The geometry of the failure mechanism in this ground condition resembles the case in sand: it exhibits a chimneylike failure mechanism, can be better described by the wedge stability models, and the maximum displacement of the ground just occurs on top of the tunnel face.
 

Key words: slurry shield, layered ground, slurry pressured, face failure

中图分类号: